Installation Manual 2KW Air Heater Diesel 12volt
[Pages:13]Contents
Page 1 Page 2 Page 3
Page 4
Page 5
Page 6
Page 7
Page 8
Page 9 Page 10 Page 11 Page 12 Page 13
Installation Manual
2KW Air Heater
Diesel 12volt
Installation Manual Cover sheet & Contents Preface Packing List Introduction Technical Specifications Parts List Heater Location Considerations Fig 8 heater measurements 11 Heater mounting Fig 14 Fuel line & Flow & Notes Fig 15 Fuel Pump mounting Fig 17 Fuel pipe Fig 20 Wiring diagram Notes on wiring Item Locations Step 1 - Fuel Tank Installation Step 2 - Installation of Fuel Filter & Pipe Step 3 - Fitting the Fuel Pump Step 4 - Heater Installation Step 5 - Installation of Electrical System Figs 9 &10 Drilling templates & Fig 12 Cold Air Inlet & Hot Air Outlet piping Step 6 - Mount the Heater Step 7 - Connection the Air inlet & Exhaust pipes Figs 22 & 23 Heater air intake & exhaust piping Preparation for Initial test Run Diesel heater control unit Basic Operation Error Codes Precautions Typical Van Installation
Preface
Thank you for choosing 2KW air parking heater. This instruction book describes the structures, installation and operation of the heater. For correct use of the heater, please read this instruction book carefully before installation and use. The instruction book should be saved in a convenient place for later reference.
Attention:
? This instruction book is subject to revision without notice. ? Our effort is to explain all questions the users may have through this instruction book. If you have any
doubts or find anything incorrect-in this instruction book, please contact our company directly. ? Unpacking, please check the heater and its accessories against the packing list. Please contact the
dealer immediately if any problem is found. ? For any trouble arising during application, please contact our company or other customer
service stations authorized by our company. We shall do our best to provide service to you.
No 1 Heater
Name
2 Wiring harness 3 Fuse
4 Fuel pump
5 Fuel pump connection wire 6 Filter 7 Fuel pipe 8 Control switch 9 Protective cushion 10 Air inlet pipe (with protective cover) 11 Exhaust pipe (with protective cover) 12 Gasket 13 Reducing T 14 Fuel pump clip 15 Air inlet pipe clip 16 Exhaust pipe clip 17 Air inlet pipe fixing clip 18 Exhaust pipe fixing clip 19 Fuel pipe joint 20 Fuel pipe clip 21 Fuel pipe clip 22 Washer 23 Nut 24 Self drilling tapping screw 25 Self drilling tapping screw 26 Self tapping screw 27 Self tapping screw 28 Cable ties 29 Oil suction pipe
Packing List Specification
12V Gasoline, 12V Diesel, 24V Diesel
12V/20A 24V/15A 12V 12V with damper 24V L=6800 Only diesel 2mm id / 5mm od L=8000 With gasket
23mm id / 26mm od L=750 22mm id / 28mm od L=700 81x110x2 10-6-10 32mm 16mm / 25mm 22mm / 26mm 24mm 27mm 4.1 id / 10.5 od L=50 9mm id / 11mm od 12mm id / 14mm od 6mm id / 18mm od M6 ST5.5*25 ST5.5*30 4*16 3*20 4*200 XYG-II 5*600
QTY
1 1
1
1 1 1 1 1 1 1 1 1 1 1 1 2 2 6 12 2 4 4 4 1 1 1 10 1
Purchase code 4W200212Q01 4W200212C01 4W200224C0 12030300203 11990002000 1990001900 33000003100 33000007600 33000003200 29030000400 33000000400 29030001300 3l010700400 12040600900 31010302600 31010302700 12040001800 120200I5700 I2010007100 12010004500 12010005000 29010003700 12010006100 12060003800 12010004200 12010004600 12010006500 12050003400 12050003100 12050003100 12050002700 12050002500 21990000000 31000000500
Introduction
The main equipment of Model 2KW air parking heater (referred to as the heater) is a small fuel furnace controlled by a single-chip micro- processor. Its furnace body (the heat exchanger) is located in the hood-shape case, which serves as independent air passage. Cold air is sucked into the air passage by the heat supplying fan and blown out when it becomes hot. This is an independent heating system for the vehicles.
The heater is fully automatically controlled. It features in compact structure, easy installation, energy-saving, environmental protection, safety and reliability, easy maintenance, etc.
Main Technical Specifications Please refer to Table 1 below for main technical specifications.
Heat Power (W)
2000
Fuel Rated Voltage Fuel Consumption Rated Power Consumption (W) Working (Environment) Temperature Working height above sea level Weight of main heater (kg) Dimensions (mm) Mobile phone control (optional) Remote control (optional)
Gasoline
Diesel
12V
12V/24V
0.14-0.27 0.12-0.24
14-29
-40?C to + 20 ?C
................
................
In order to avoid copyright disputes, this page is only a partial summary.
To fulfill the demand for quickly locating and searching documents.
It is intelligent file search solution for home and business.
Related download
- scout state hot water heater systems
- application selection installation guide
- hamshack hotline
- hot categories report ebay
- ignition 101 gas ignition systems kidde fenwal inc
- measuring the benefits to sniping on ebay evidence from a
- chapter 6 mechanical systems performance objectives
- owners manual leisure spa
- hot salts bluing
- stanford university
Related searches
- kohler generator installation manual pdf
- air force manual vs instruction
- manual air dampers
- air force manual afman 23 122
- air force manual 23 110
- air conditioner installation cost
- home air conditioner installation cost
- air conditioner installation estimate
- air conditioner installation cost calculator
- window air conditioner installation cost
- air conditioner installation home depot
- ductless air conditioner installation cost