Hiepro.ehawaii.gov



Specification for a Two (2) Rear Axle Tractor:Model Year: New 2019 or later.Model: Truck Tractor which hauls low bow, water tanker and refuse to transfer stations.GVWR: 72,000 lbs. minimum or manufacturer’s standardWheelbase: Manufacturer’s standard to comply with the GVWR and configuration with 210” wheel base.Frame and Equipment:10-3/4” Steel rails to 354”Full Steel Inner LinerHeavy-Duty Iron Front Spring BracketsZinc Coated Anti Corrosion Treated Framer RailsEOF Tractor Tapered with XmbrRear Mudflaps and Coil HangersHolland FW35 Fifth Wheel Top PlateFifth Wheel Setting Behind C/L Bogie 8”Fifth Wheel RampsLH Fifth Wheel Release6.6” – 7” Fifth Wheel HeightHolland Heavy Duty Air Slide36” Air SlideFrame Mounted Deck Plate and Access Pkg, Both SidesFront Axle & Equipment:Meritor MFS+13B 13,200 lb., 3.5” DropTaper Leaf Springs, Shocks 13,200 lb.Power Steering TRW TAS65Power Steering Reservoir Frame Mounted w/CoolerPHP10 Iron PreSet PLUS Hubs-Air DiscSevere Service Disc Brake RotorAir Disc Front BrakesMeritor wide Track IPO Standard, Front AxlePad Dust Shields for Air Disc Brakes; Front AxleRear Axle & Equipment:Meritor RT46-160 46,000 lb.PHP10 Iron PreSet PLUS HubsLong Stroke Parking Brakes, Drive Axle(s)Dust Shields for Cam Brakes, Drive Axle(s)Bendix Smart ATC Traction ControlRefuse Service Brakes, Steer and Drive AxlesRear Brake Camshaft ReinforcementLube Pump, Drive Axle(s)Gusseted Cam brackets, Drive Axle(s)ISO 3731 Connector with Trailer ABS Power on Pin7Anti-Lock Braking System (ABS) 6S6MSynthetic Axle Lubricant All AxlesBendix Air Cam Rear Drum Brakes 16.5x7Diff Lock Tandem AxlesRatio 4.89 Rear AxleAir Trac 46,000 lbs., 54” Axle SpacingAir Springs, Internal BumpersLocate Single Leveling Valve Forward Drive AxleDash Mounted Dump Switch with Indicator LightEngine & Equipment:X15 565@1950 GOV@2000 2050@1150Engine Idle Shutdown Timer DisabledEnable EIST Ambient Temp OverruleEff EIST NA Expiration MilesEffective VSL Setting 65.0 MPH or GreaterRemote PTO and Throttle ProvisionCARB Engine Idling Compliance-declined.Steel Front Engine support IPO Standard AluminumPACCAR 160 Amp Alternator, BrushedPACCAR 12V Starter, N/A PACCAR MX Engines4 PACCAR Premium 12V Dual Purpose Batt 290 CCABattery Jumper Terminals Mounted in FrontKissling Battery Disconnect Switch, 300 amp2-Speed Fan Clutch for frequent Start/StopsNaturally aspirated 18.7 CFM Air CompressorInterbrake (Furnished on engine)PACCAR Fuel/Water Separator Standard ServiceFuel Heat for Fuel FilterNo Electric Heat Option for fuel filterEngine Protection ShutdownHigh Efficiency Cooling SystemAir Cleaner Firewall MountedExhaust Single RH Side of CabCurved Tip Standpipe36” H, 5” Dia Chrome, Clear Coat StandpipeTransmission & Equipment: Eaton RTLO29018B 18-speedSPL250 Lite HT Driveline, 1 Midship BearingSPL170 XL Driveline InteraxleAluminum Transmission Bell Housing IPO IronManual Shifter, BlackHeavy Duty Input Bearing for PTO OperationAir Trailer & Equipment: Bendix AD-IS EP Air Dryer with HeaterPull Cords All Air TanksWire Braid Chassis HoseSteel Painted Air TanksSelf Returning Brake Hand Valve; Column MountedAdditional A&E Lines in EOF w/Diversion Valve w/one15’ A&E Lines Coiled & Two 7-way PlugsA&E Connections BOC/BOS with Hose TennaTire & Wheels: FF: BR 16ply 11R24.5 R250EDRR: BR 14ply 11R24.5 M726ELACode-rear Tire Quantity 8FF: Alcoa 985657 24.5x8.25 Clean Buff FinishRR: Alcoa 985657 24.5x8.25 Clean BuffCode-rear Rim Quantity 8Schrader 1126 Double Seating ExtensionFuel Tanks: 26” Aluminum 120 Gallon Fuel Tank RH BOCLocation RH BOC 120 GallonFuel Tank Fill CenterFuel CoolerAdditional Thread Boss on Upper Hydraulic TankLocking Fuel Tank Cap(s)DEF Tank Mounted LH BOCStandard DEF to Fuel Ratio 2:1 or GreaterPolished Stainless Steel Cover for DEF TankDEF Tank Small26” Aluminum 100 Gallon Hydraulic Tank LH BOC AdBattery Box & Bumper: Aluminum Battery Box LH Under Cab, Non-Slip StepAftertreatment RH U/C Aluminum Non-Slip Cab EntryAluminum Bumper Deep Taper Stainless Steel CladBumper Toe Step CutoutCab & Equipment: Aluminum Cab 123” BBC Fiberglass Hood SFFASmartSound Cab Insulation PackageKeyless EntrySears Atlas 70 Driver SeatUltraride Passenger SeatDrivers Armrest-RH onlyPassengers Armrest-LH OnlyAir Ride DriverHigh Back DriverVinyl DriverNon-Air Ride PassengerHigh Back PassengerVinyl PassengerAdjustable Steering Column-Tilt/TelescopeCab Rear Corner Windows-Standard TintDark Window Tint IPO STD Tint-Day CabExtended Rear Window IPO STD Window-Day CabDay Cab Rear WindowTwo Piece Flat WindshieldPower Lift Windows-Both DoorsCombo Fresh Air Heater/Air ConditionerOutside Sunvisor-Stainless SteelMirrors SSTL Each Side Heated/Motorized(2) Convex 8” SS MirrorsConcert Class w/CD, Bluetooth and AudioMidlevel Speaker Package for CabSmart LINQ Remote DiagnosticsPlug-In Auto Reset Circuit BreakerAdditional 12V Power Outlet-Dash MountedRemovable Bugscreen Behind GrilleElectric Windshield WipersUnibilt Cab Air SuspensionTriangle Reflector KitFire Extinguisher, Cab mounted. Hazmat approved UL Listed/Reted ABCBackup AlarmMain Transmission Temperature GaugeAxle Temperature Gauges, Tandem DriveEngine Oil Temperature GaugeGuard(s) for Rear Axle Heat GaugeAir Application GaugeAir Restriction Gauge on DashAir Restriction IndicatorFuel Filter Restriction GaugeAnalog Electric Clock, Dash MountedBright Bezel GaugesMain Instrumentation Panel, Graphics DisplayUp to 6 Additional Rocker Switches in ID PanelHeadlight Single Pod Mtd, Hella Vision Plus(5) Marker Lights, AERO LED(2) LED Strobe Lights Roof Mtd Each Side Cab RoofDash Switch & Light for Ignition Power to J560Courtesy Lights Mounted Under CabDaytime Running LightsLED Stop/Turn/Tail/BackupAdditional LED Round Turn Signal(2) Load Lights, Bracket Mounted Inboard Loc KPaint: Standard Paint Color Selection-White (exterior) and Gray (interior)Doors: All door locks shall be powered and controlled by driver only; except that the front-passenger door-lock to be also operative by front passenger. 2 dootsOther: Equipped with Kenwood (VM 7000) Dual Band. 7/800 MHZ (HIWIN)/ VHF Digital. Vehicle Mount Radio Operator’s Manual. Electronic format is acceptable. Service and repair manuals (2 sets). Electronic format is acceptable.Warranty: 1 year/100,000 milesDelivery Addresses / Authorized Facility Representative(Locally available unit preferred)Bid Item: (One) Two Rear-Axle Tractor Kulani Correctional FacilityHC 01 Stainback HwyHilo, Hawaii 96720Contact Person:Chester Cross(808) 932-4452GENERAL SPECIFICATIONSIn addition to detailed specifications herein, the following requirements shall form a part of these specifications:Vehicle offered shall include any other standard features not listed but detailed in the manufacturer’s brochures and deemed necessary for the proper and safe operation of the vehicle.Manufacturer’s standard warranty of 1 year/100,000 miles. Full coverage shall include cost of parts, labor and any other expenses incurred in performing warranty work. Warranty documents shall be delivered with the vehicle and shall detail manufacturer’s obligation and warranty.Contractor shall provide two copies of the owner-operator manual and service/repair manual at the time the vehicle is delivered. Hard copies are required if available. Electronic version is acceptable provided the electronic version is printable with no material omissions.Vehicle shall include and comply with all Federal Motor Vehicle Safety Standards. Vehicle shall also comply with the Code of Federal Regulations, Title 40, Part 85: Control of Air Pollution from New Motor Vehicles and new Motor Vehicle Engines; Environmental Protection Agency.Vehicle shall be completely serviced and in full operational condition upon delivery.Accessory or standard equipment installed on the vehicle shall be fully guaranteed by the Contractor against defects resulting from the use of defective or inferior materials or from neglect or from defective workmanship or against all design and manufacturing defects. Warranty period shall begin from the date equipment is placed in service and shall be for a minimum period of one (1) year or for the period guaranteed by the manufacturer, whichever is longer except for rust proofing. Warranty documents shall be delivered with the vehicle and shall detail manufacturer’s obligation and warranty procedures. Contractor shall replace or repair defective material and/or workmanship at no cost to the State for parts and labor during the warranty period, provided such defects are not due to abuse or negligence on the part of the State.All equipment offered shall meet ANSI and OSHA safety requirements, and any other Federal or State safety requirements. If applicable or when requested, equipment shall bear a label or written documentation indicating approval of safety requirements from a bonafide testing laboratory.Manufacturer’s standard Corrosion Protection warranty for a minimum of five (5) years, 60,000 miles and warranty documents.MANUALS/TECHNICAL/SERVICE BULLETINS: Successful bidder shall furnish a set of factory service Bulletins: manuals containing system description/service procedures; a set of service special manuals, service labor time, Power train control/emission diagnosis manuals, specified vehicle parts books. All manuals are to be complete and furnished with the delivery of the vehicle. (Electronic format is acceptable).All technical and service bulletins pertaining to service/repair revisions and identification of new replacement parts from the vehicle manufacturer shall be provided by the successful bidder to the Division of Administration-Office Services Section on a timely basis.CONTRACTOR SHALL INSTALL VEHICLE GRAPHICS: Contractor shall coordinate with ASO or designated facility to obtain and install State of Hawaii supplied vehicle graphics to exterior of vehicle. Note: Verify vehicle ordered has not had a major body model change, which may impede the graphics installation of State of Hawaii supplied graphics set. ................
................

In order to avoid copyright disputes, this page is only a partial summary.

Google Online Preview   Download