The comparison between different systems to prepare ...



The comparison between different systems to prepare platelet rich plasma using equine blood

L.N. Hessel, G. Bosch and C. van der Lest

Veterinary Faculty, University of Utrecht, The Netherlands

Keywords: horse; tendon; platelet rich plasma; growth factors

Summary

Reasons for performing study: To compare different platelet rich plasma production systems with regard to the composition of the end-product.

Hypothesis: There are differences in resulting platelet and leukocyte concentrations and other characteristics using different techniques.

Material/methods: blood from six horses was used to produce PRP with five different techniques. The end-products were analyzed for hematologic parameters, such as platelet and leukocyte concentrations, and growth factor levels, namely PDGF-BB and TGF-ß1.

Results: All systems showed an increase in platelets and growth factors compared to the baseline, but the differences between the systems were significant. Platelets increased in a range from 1.33 to 6.72 times compared to whole blood, PDGF-BB had a mean baseline of 0.44 ng/mL in plasma and showed mean concentrations ranged from 0.85 to 5.27 ng/mL and mean TGF-ß1 concentration increased in a range from 0.6 to 1.70 ng/mL in comparison with a mean baseline of 0.30 ng/mL. Leucocyte concentrations varied a lot between the systems, with a decrease in one system and a mean increase ranging from 1.46 to 7.58 times the baseline in the other systems.

Conclusions and potential relevance: This study revealed some interesting differences in hematologic parameters between different systems to prepare PRP. It also showed that there a great differences in growth factor concentrations between the systems. Leukocytes and its contribution to or negative effects on the healing process remain unclear. The findings of this study show the characteristics of PRP using several techniques that are commercially available. The differences between the systems will give practitioners an insight in the system they prefer.

Introduction

The flexor tendons in the lower limbs of horses are important weight-bearing structures at rest as well as during locomotion. Injuries to these structures heal slowly and inefficiently, because the scar tissue that is formed in this repair is functionally deficient compared to normal tendon. This has important consequences for the animal in terms of reduced performance and an increased risk of re-injury (Richardson et al. 2007).

The healing of the tendon follows a sequence of events consisting of inflammation, fibroblastic proliferation, collagen production and remodelling. Pain is most closely correlated with the degree of inflammation, but not necessarily with the amount of damage done to the tendon – demonstrated by lameness and pain on palpation of the affected tendon, which is short-lived. Soon after the clinical injury, the proliferation phase begins which overlaps with the inflammatory phase. This is associated with vascular in-growth and cellular infiltration (Smith 2008). After this period, linearly arranged Type I collagen fibrils prevail, indicating progressive remodelling and normalization of the healing tissue. The disorganized scar tissue can, if given long enough, reach similar ultimate strength as the original tendon. However, it is the abnormal composition and arrangement of matrix in fibrous scar tissue, which has poor biomechanical properties in comparison to normal tendon, and the slow rate of healing that are believed to be responsible for the high incidence of re-injury (Dowling et al. 2000).

Most treatments attempt to decrease inflammation within the tendon, prevent further trauma to damaged tissues, stimulate the healing process, and prevent re-injury after the horse resumes training. High rates of recurrence of tendon injury have stimulated researchers to look for methods for modulating tendon healing that provide better repair in comparison to the original tendon architecture (Nixon et al. 2008).

One of the treatments currently available is the use of platelet-rich plasma (PRP). It is derived from the patients own whole blood, which is its most important advantage, as there is no need for concern about transmissible diseases or immune reactions. PRP contains platelets which upon activation release growth factors and other substances that promote tissue repair. Growth factors like Platelet-Derived Growth Factor (PDGF), Transforming Growth Factor-ß (TGF-ß) and Vascular Endothelial Growth Factor (VEGF) stimulate cell proliferation and differentiation, and increased extracellular matrix production. (Hsu et. al 2004; Anitua et. al 2004). It may also contain leucocytes and other mediators which play a crucial role in inflammatory responses. Several human studies have pointed out the key role of leucocytes in PRP, both for their anti-infectious action and immune regulation (Dohan Ehrenfest et al. 2008). Others studies were concerned about the pro-inflammatory mediators and their potential for inciting an undesirable inflammatory reaction in affected tendons (Scott et al. 2004; Schnabel et al. 2007; Cissel et al. 2010).

PRP is already been used in many different clinical applications, demonstrating the effectiveness and importance of the product for a variety of medical procedures. For example, Maia et al. (2009) treated six horses with PRP. They induced tendinopathy by injecting collagenase in the superficial digital flexor tendon of the horses and treated them twelve days later. The animals were subjected to daily physical examination and clinically monitored twice per week. Thirty-six days after inducing the tendinopathy, histologic evaluation showed that the injuries treated with PRP healed with a more uniform and organized repair tissue compared to the control group. Another study was performed by Bosch et al. (2010). The hypothesis that a single intratendinous PRP treatment affects on the repair tissue in surgically induced core lesions in tendons of horses was confirmed. Rindermann et al. (2010) used autologous conditioned plasma as therapy of tendon and ligament lesions in seven horses. All horses revealed a positive outcome in 10 to 13 months post injury and were either performing in their previous work-load or were back in full training.

A lot of systems that prepare PRP are commercially available. Most of them use centrifugation, but also filtration and a manual technique are being used. In human research much research has been conducted to detect differences between the systems. They all showed that there are differences in number of platelets and therefore in concentration of different growth factors, but also inclusion of leukocytes and use of activators that may lead to different biological effects when it is used as therapy (Everts et al. 2006; Sanchéz et al. 2010; Lopez-Vidriero et al. 2010).

These human systems are also used in the veterinary field, but there is no data for the PRP production techniques on the resulting platelet and leukocyte concentrations and other characteristics. Therefore, the goal of this study is to compare different systems with regard to the composition of the end-product.

Material and Methods

PRP preparation

Six warmblood horses were used with a mean age of 14 years old (range 9-17) and a mean weight of 543 kg. (range 488-584 kg). All the horses were shaved before drawing blood, to prevent contamination. The blood was collected aseptically from a jugular vein using a 18 G needle. All the syringes were inverted a couple of times to ensure proper mixing with the anti-coagulant before PRP was prepared. A 60 ml syringe was pre-filled with 6 ml of citrate solution and filled up to 60 ml with whole blood. This was put in the Angel system (Cytomedix, Gaithersburg, MD, USA) and prepared following manufacturer’s instructions. Following centrifugation at 3200 rpm for 16 minutes, the PRP was collected in a 20ml syringe and diluted to a volume of 6ml using plasma volume from the platelet poor plasma collection bag.

10 ml whole blood, without an anti-coagulant, was taken from the horse for the ACP Double Syringe System, (Arthrex, Naples, FL, USA) and also prepared following manufacturer’s instructions. The syringe was put in a Rotofix 32A centrifuge and rotated at 1500 rpm for 5 minutes. A second syringe, already in the first was then pushed down to collect the plasma, which is the end-product.

A 60 ml syringe with 6 ml of the attached anti-coagulant was prepared to PRP with the E-PET (Pall Corporation, Port Washington, NY, USA) following manufacturer’s instructions. The anti-coagulated venous blood taken from the horse is mixed with a capture solution in the collection bag before passed through Pall’s cell harvest device where platelets are captured. Back-flushing the harvest solution through the filter recovers the platelet concentrate into a syringe.

Another 60 ml syringe with 6 ml of the attached anti-coagulant was used to prepare PRP with the GPSIII (Biomet, Warsaw, IN, USA), also following manufacturer instructions. The blood was put in the GPS tube and placed in the centrifuge. It was centrifuged for 15 minutes at 3200 rpm. Afterwards, the platelet poor plasma is extracted through a special port and discarded from the device. While the PRP is in a vacuumed space, the device is shaken for 30 seconds to re-suspend the platelets. Afterwards the PRP is withdrawn.

The last syringe was used to prepare PRP manually. The 60 ml of anti-coagulated venous blood was divided over six 10 ml tubes and placed in an EBA20 centrifuge (Hettich, Tuttlingen, Germany). This was set on 1800 rpm for 10 minutes. After the first round was finished the buffy coat was taken out of the tubes with a pipette and placed in a new tube. This was again centrifuged at 1800 rpm for 10 minutes and the actually PRP was the buffy coat suspended in the supernatant. This procedure was used as described by De Mos et al. (2009).

Hematological evaluation

Blood samples, approximately 3.5 ml, used for baseline measurements were drawn from the horses. Another 10 ml of blood was used to prepare plasma for further analysis. After the procedures were done, the entire PRP product was taken for hematologic evaluation by an ADVIA® 120 Hematology System (Siemens Healthcare Diagnostics B.V., Breda, The Netherlands) This machine counts platelets, leukocytes and erythrocytes, and it calculates the Mean Platelet Volume (MPV) and Mean Platelet component Concentration (MPC).

After this analysis the whole blood and the PRP products where divided in Eppendorfes. These cups were placed in a freezer with a temperature of -80 ºC till further analysis.

Biochemical evaluation

Platelet growth factor concentrations, PDGF-BB and TGF-β1, were determined in whole blood, plasma and five PRP samples using a sandwich enzyme immunoassay technique (R&D Systems, Minneapolis, MN, USA) according to the manufacturer’s instructions. Samples were measured in duplicate and in appropriate dilutions to fit the respective calibration curves. Cross reaction has been assumed on homology between equine and human protein structure (Schabel et al. 2007)

Statistical analysis

Data were analyzed statistically using SPSS® 16.0 (SPSS Inc, Chicago, IL, USA). Data for hematological and biochemical testing, which were non parametric and repeated measurements, were tested using a Friedman test. The scores were compared using a Wilcoxon Signed Ranks test. The significance level was set at P ≤ 0.05.

Results

PRP preparation

Six horses were used to determine differences between five systems that prepare PRP. After putting the blood in a system, it did not take long before the end-product was ready, approximately 10 to 30 minutes. The manual technique takes longer, because the blood has to be in the centrifuge twice for 10 minutes and it takes skills and therefore time to extract the buffy coat. This makes the manual method the most time conceiving method and the method most prone to mistakes.

Hematological parameters

All the systems showed a significant increase in platelets compared to whole blood, except the Angel. The Arthrex showed a minimum increase and the GPS the most (table 1). Significant differences were seen between the GPS with all systems, between the E-PET with the Angel and the Arthrex, and between the manual technique with the Arthrex.

Table 1 shows a decrease in MPV and a correlated increase in MPC in almost all systems. Differences between the systems are all significant, except for the differences between the manual technique and the Angel and the Arthrex, and between the GPS and Arthrex.

Table 1. Hematological parameters

|Parameter | |Whole blood |Angel |Arthrex |E-PET |GPS III |Manual |

| | |(n=6) |(n=6) |(n=6) |(n=6) |(n=6) |(n=6) |

|Platelets (%) |Mean | |232.0 |133.8 |444.8 |672.3 |408.9 |

| |Range | |47.7 - 378.7 |74.2- 156 |311 - 565 |393 - 1259 |203 - 565 |

|MPV (fL) |Mean |9.5 |9.6 |7.1 |5.7 |7.0 |8.3 |

| |Range |8.8 – 10.2 |7.4 – 10.8 |5.0 – 8.7 |4.9 – 6.9 |5.9 – 9.2 |5.2 - 9.7 |

|MPC (g/L) |Mean |207 |197 |259 |286 |260 |227 |

| |Range |198 – 219 |188 – 213 |224 – 303 |243 - 305 |226 - 287 |216 - 238 |

|Leucocytes (%) |Mean | |146.6 |10.3 |210.7 |758.2 |160.2 |

| |Range | |36.1 - 235 |3.2 – 16.6 |165 - 250 |610 - 1253 |89 - 450 |

The GPS showed a significant increased level of leucocytes compared to whole blood. The Angel, E-PET and manual technique also showed in increase, but this was not significant. The Arthrex system showed a significant decrease in leukocytes. Between the systems there was a significant difference between all systems with the Arthrex system, and between the GPS with the Angel and the E-PET.

All hematologic parameters are shown in graphics in annex 1.

Growth factors

The counts in the growth factors concentrates obtained by the five methods were significantly greater than in plasma, except for TGF-ß by the Arthrex system (table 2). The concentrations of PDGF-BB were significantly different between the E-PET with the Angel, the Arthrex and the manual technique. The GPS system also differ significantly with the Angel, the Arthrex and the manual technique and there was a significant difference between the Angel and the Artrex. For TGF-ß the concentrations were significantly different between all systems with the Arthrex and between the E-PET with the Angel, the Arthrex and the GPS.

PDGF-BB and TGF-ß1 are shown in graphics in annex 2.

Table 2. Growth factor concentrations

|Parameter |Plasma (n=6) |Angel (n=6) |Arthrex (n=6) |E-PET (n=6) |GPS III (n=6) |Manual (n=5) |

|PDGF-BB (ng/ml) |0.44 ± 0.18 |2.44 ± 0.62 |0.85 ± 0.05 |5.27 ± 1.47 |5.14 ± 1.02 |1.61 ± 0.59 |

|TGF-ß1 (ng/ml) |0.30 ± 0.04 |0.6 ± 0.05 |0.28 ± 0.08 |1.70 ± 0.38 |0.68 ± 0.26 |1.58 ± 0.59 |

Discussion

In this study it is shown that the platelet and leukocyte concentrations may differ in the PRP end-products prepared by different systems. The production of growth factors and prostaglandins are also influenced by the different preparation techniques. The goal of this study was to increase knowledge on whether different PRP preparation methods result in different growth factor release. In addition, the leukocytes and it features were investigated because of its role in inflammatory responses.

It all starts with producing the PRP. Most systems use a centrifuge to harvest the end-product. This means it should be done in a clinic where the proper materials are available. In the current study we used one system that did not need a centrifuge, being the E-PET system. This filtration system only has to be hung so that the blood can flow through the filter. This means that the collection can be done near the stables were the patient is held, which might be an advantage of this system.

Time is not a big issue in this matter. All systems need approximately 10 – 30 minutes to produce the PRP. Except for the manual system, which takes about 50 minutes. This is not only due to its long centrifuge time but also because it takes skills to extract the buffy coat. It is also the most unreliable technique, because extracting the buffy coat is precise work and depends on the experience of the person doing the extraction. This in contrary to the other techniques where the materials are developed to be as precise as possible.

Although the exact mechanisms of action of PRP remain unclear, the evaluated levels of PDGF and TGF-β in PRP can be assumed to play an important role, as both have shown to positively influence tendon healing. PDGF plays a role in the acute phase after tendon damage, and stimulates the production of other growth factors; TGF-β is active during the inflammatory phase, and it has several effects in cell migration and proliferation (Bosch et al. 2010).

All systems showed an increase in platelets and growth factors compared to the baseline, but the differences between the systems were great. The Arthrex system showed a mean increase of platelets of 133.8%, which is a similar result to study of Rindermann et al. (2010). The PDGF was concentrated twice and the TGF-ß was not concentrated at all. The generally accepted increase of platelets numbers is three to five-fold the baseline. The Arthrex system did not reach this increase, which could be explained by the method it used; it is thought that the system uses plasma which does not contain platelets (platelet poor plasma).

The GPS system showed the largest increase in platelets (672.3%), but not in growth factors. The PDGF concentration was very well elevated, 13-fold the plasma level, but the TGF-ß did not show the same increase. The E-PET also showed high results with an increase of 444.8% in platelets and a respectively 5-fold increase in PDGF and almost a 2-fold increase in TGF-ß compared to the baseline. Both systems showed a platelet concentration that was far above the generally accepted increase, but it is unknown whether these high platelet levels might have negative effects.

Although the manual technique is time consuming and less reliable than other techniques, it did show an increase in both platelets (408.9%) as growth factors (5.1 times and 4.6 times for respectively PDGF and TGF-ß). It might be used in practice, when the user is experienced enough. The Angel system did also increase in both platelet concentration and growth factor levels, but was significantly different with the GPS and E-PET system for the platelets as well as PDGF.

The Mean Platelet Component (MPC) provides information on density, or granularity, of platelets and indirectly on their structure and function. MPC is reduced when platelets degranulate, which is an indication that the platelets have undergo activation (Diaz-Ricart et al. 2010). Another platelet function parameter is the Mean Platelet Volume (MPV), showing the mean of the distribution of cells by volume. Measuring platelet size is also a potential marker of platelet reactivity. Larger platelets are denser and contain more α-granules, which release growth factors, making these platelets more metabolically and enzymatically active (Chu et al. 2010). In the present study only the Angel system showed an activation of platelets.

PRP may also contain leucocytes which play a crucial role in inflammatory responses, but there is little known about leucocytes present in PRP and their contribution to the healing process (Everts et al. 2006). Several human studies have pointed out the key role of leucocytes in PRP, both for their anti-infectious action and immune regulation (Dohan Ehrenfest et al. 2008). They also mentioned the production of large amounts of vascular endothelial growth factor (VEGF) by leucocytes, which is an angiogenesis stimulator.

Others studies were concerned about the pro-inflammatory mediators and their potential for inciting an undesirable inflammatory reaction in affected tendons (Schnabel et al. 2007). There is data that prostaglandins degrade tendon extracellular matrix (Cissell et al. 2010) and that matrix metalloproteinases (MMP), produced by neutrophils, and reactive oxygen species degrade matrix, and both leading to local inflammation and damaging the surrounding tissue. (Scott et al. 2004; Kaux et al. 2010). Cytokines such as tumour necrosis factor-alfa and interleukin 1, can upregulate MMP and cyclooxygenase 2, which have damaging effects on the extracellular matrix and resident cells of tissues as tendons and ligaments (Argüelles et al. 2008).

More research about the role of leucocytes and other inflammatory mediators in the healing process of tendon tissue is needed. This is necessary to answer the question whether or not leucocytes must be present in PRP.

In conclusion this study revealed some interesting differences in hematologic parameters between different systems that prepare PRP. It also showed that there are great differences in growth factor concentrations between the systems. Leukocytes and their contribution to or negative effects on the healing process remain unclear.

This research managed to reach its goal to compare different systems regarding the composition of the end-product. Practitioners using PRP to treat tendon injuries now have more knowledge about the characteristics of the techniques that are commercially available and this may help them choose for a systems they thinks is best.

References

1. Agut A, Martinez ML, Sanchez-Valverde MA, Soler M, Rodriguez MJ. Ultrasonographic characteristics (cross-sectional area and relative echogenicity) of the digital flexor tendons and ligaments of the metacarpal region in Purebred Spanish horses. Vet J 2009; Jun;180(3):377-83.

2. Anitua E, Andia I, Ardanza B, Nurden P, Nurden AT. Autologous platelets as a source of proteins for healing and tissue regeneration. Thromb Haemost 2004; Jan;91(1):4-15.

3. Arguelles D, Carmona JU, Climent F, Munoz E, Prades M. Autologous platelet concentrates as a treatment for musculoskeletal lesions in five horses. Vet Rec 2008; Feb 16;162(7):208-11.

4. Bosch G, van Schie HT, de Groot MW, Cadby JA, van de Lest CH, Barneveld A, et al. Effects of platelet-rich plasma on the quality of repair of mechanically induced core lesions in equine superficial digital flexor tendons: A placebo-controlled experimental study. J Orthop Res 2010; Feb;28(2):211-7.

5. Chu SG, Becker RC, Berger PB, Bhatt DL, Eikelboom JW, Konkle B, et al. Mean platelet volume as a predictor of cardiovascular risk: a systematic review and meta-analysis. J Thromb Haemost 2010; Jan;8(1):148-56.

6. Cissell JM, Milton SC, Dahlgren LA. Investigation of the effects of prostaglandin E on equine superficial digital flexor tendon fibroblasts in vitro. Vet Comp Orthop Traumatol 2010;23(6):417-23.

7. de Mos M, van der Windt AE, Jahr H, van Schie HT, Weinans H, Verhaar JA, et al. Can platelet-rich plasma enhance tendon repair? A cell culture study. Am J Sports Med 2008; Jun;36(6):1171-8.

8. Diaz-Ricart M, Brunso L, Pino M, Navalon F, Jou JM, Heras M, et al. Preanalytical treatment of EDTA-anticoagulated blood to ensure stabilization of the mean platelet volume and component measured with the ADVIA counters. Thromb Res 2010; Jul;126(1):e30-5.

9. Dohan Ehrenfest DM, Rasmusson L, Albrektsson T. Classification of platelet concentrates: from pure platelet-rich plasma (P-PRP) to leucocyte- and platelet-rich fibrin (L-PRF). Trends Biotechnol 2009; Mar;27(3):158-67.

10. Dowling BA, Dart AJ, Hodgson DR, Smith RK. Superficial digital flexor tendonitis in the horse. Equine Vet J 2000; Sep;32(5):369-78.

11. Everts PA, Brown Mahoney C, Hoffmann JJ, Schonberger JP, Box HA, van Zundert A, et al. Platelet-rich plasma preparation using three devices: implications for platelet activation and platelet growth factor release. Growth Factors 2006; Sep;24(3):165-71.

12. Georg R, Maria C, Gisela A, Bianca C. Autologous conditioned plasma as therapy of tendon and ligament lesions in seven horses. J Vet Sci 2010; Jun;11(2):173-5.

13. Hsu C, Chang J. Clinical implications of growth factors in flexor tendon wound healing. J Hand Surg Am 2004; Jul;29(4):551-63.

14. Kaux JF, Le Goff C, Renouf J, Peters P, Lutteri L, Gothot A, et al. Comparison of the platelet concentrations obtained in platelet-rich plasma (PRP) between the GPS II and GPS III systems. Pathol Biol (Paris) 2010; Dec 7;.

15. Lopez-Vidriero E, Goulding KA, Simon DA, Sanchez M, Johnson DH. The use of platelet-rich plasma in arthroscopy and sports medicine: optimizing the healing environment. Arthroscopy 2010; Feb;26(2):269-78.

16. Maia L, Souza MVd, Ribeiro Junior JI, Oliveira ACd, Alves GES, Benjamin LdA, et al. Platelet-rich plasma in the treatment of induced tendinopathy in horses: histologic evaluation. Journal of Equine Veterinary Science 2009;29(8):618-26.

17. Nixon AJ, Dahlgren LA, Haupt JL, Yeager AE, Ward DL. Effect of adipose-derived nucleated cell fractions on tendon repair in horses with collagenase-induced tendinitis. Am J Vet Res 2008; Jul;69(7):928-37.

18. Richardson LE, Dudhia J, Clegg PD, Smith R. Stem cells in veterinary medicine--attempts at regenerating equine tendon after injury. Trends Biotechnol 2007; Sep;25(9):409-16.

19. Sanchez M, Anitua E, Lopez-Vidriero E, Andia I. The future: optimizing the healing environment in anterior cruciate ligament reconstruction. Sports Med Arthrosc 2010; Mar;18(1):48-53.

20. Schnabel LV, Mohammed HO, Miller BJ, McDermott WG, Jacobson MS, Santangelo KS, et al. Platelet rich plasma (PRP) enhances anabolic gene expression patterns in flexor digitorum superficialis tendons. J Orthop Res 2007; Feb;25(2):230-40.

21. Scott A, Khan KM, Roberts CR, Cook JL, Duronio V. What do we mean by the term "inflammation"? A contemporary basic science update for sports medicine. Br J Sports Med 2004; Jun;38(3):372-80.

22. Smith RK. Mesenchymal stem cell therapy for equine tendinopathy. Disabil Rehabil 2008;30(20-22):1752-8.

Annex 1: Hematologic parameters

[pic]

Annex 2: Growth factor concentrations

................
................

In order to avoid copyright disputes, this page is only a partial summary.

Google Online Preview   Download