Tumbler Operation/Maintenance Manual
Operation/Maintenance/Programming
Drying Tumblers
Refer to Page 3 for Model Numbers
NOTA: El manual en espa?ol aparece despu?s del manual en ingl?s.
HIGH TEMP
MED TEMP
START
25C
LOW TEMP
NO HEAT
1 SELECT TEMP
2
INSERT COIN
3
PUSH START
1 SELECT TEMP
2
INSERT COIN
3
PUSH START
HIGH TEMP
MED TEMP
START
25C
LOW TEMP
NO HEAT
T433I
T477C
T478C
Keep These Instructions for Future Reference.
(If this machine changes ownership, this manual must accompany machine.)
Part No. M414462R1 March 2001
In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1 "National Fuel Gas Code" and Standard ANSI/NFPA 70 "National Electric Code".
In Canada, installation must comply with Standards CAN1-B149.1 or CAN1-B149.2 codes for gas burning appliances and equipment and CSA C22.1, latest edition, Canadian Electric Code, Part I.
In Australia, installation must comply with the Australian Gas Association Installation Code for Gas Burning Appliances and Equipment.
WARNING
FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.
W033
? Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
? WHAT TO DO IF YOU SMELL GAS: ? Do not try to light any appliance. ? Do not touch any electrical switch; do not use any phone in your building. ? Clear the room, building or area of all occupants. ? Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions. ? If you cannot reach your gas supplier, call the fire department.
? Installation and service must be performed by a qualified installer, service agency or the gas supplier.
W052
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
W053
MISE EN GARDE
POUR VOTRE S?CURIT? il est imp?ratif de suivre les instructions de ce manuel pour minimiser les risques d'incendie ou d'explosion et pour ?viter les dommages mat?riels, les blessures corporelles ou la mort.
W033Q
? Ne pas entreposer ni utiliser d'essence ni d'autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil.
? QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ : ? Ne pas tenter d'allumer d'apareil. ? Ne touchez ? aucun interrupteur. Ne pas vous servir des t?l?phones se trouvant dans le b?timent o? vous vous trouvez. ? ?vacuez la pi?ce, le b?timent ou la zone. ? Appelez imm?diatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du fournisseur. ? Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le service des incendies.
? L'installation et l'entretien doivent ?tre assur?s par un installateur ou un service d'entretien qualifi? ou par le fournisseur de gaz.
W052Q
POUR VOTRE S?CURIT?
Ne pas entreposer ni utiliser d'essence ni d'autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil.
W053Q
IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the above safety information must be posted in a prominent location near the tumbler for customer use.
M414462
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
1
Table of Contents
Introduction......................................................................................... 3 Model Identification ............................................................................. 3 Customer Service.................................................................................. 4 Wiring Diagram .................................................................................... 4 Nameplate Location.............................................................................. 5
Safety Information.............................................................................. 7 Important Safety Instructions ............................................................... 8
Operating Instructions ....................................................................... 11 Step 1: Clean Lint Screen/Compartment .............................................. 11 Step 2: Load Laundry ........................................................................... 11 Step 3: Determine Required Temperature ............................................ 11 Step 4: Determine Control Type........................................................... 11
Manual Timer Tumblers .................................................................. 12 Electro-Mechanical Coin Control Tumbler ..................................... 13 NetMaster Coin Control................................................................... 14 NetMaster Card Control................................................................... 15 Electronic OPL Control ................................................................... 16 Electronic Coin Control ................................................................... 17 Reversing Operation ........................................................................ 18 Reverse Control Switch ................................................................... 18
Programming the Electronic OPL Control...................................... 19 Signal .................................................................................................... 20 Reversing .............................................................................................. 20 Status Lights ......................................................................................... 20 Automatic Dry and Condition Mode .................................................... 21 Time Dry and No Heat Modes.............................................................. 22 Custom.................................................................................................. 23
Custom Cycle Record ..................................................................... 23 Special Cycle Mode.............................................................................. 24 Special Time Mode............................................................................... 24 Security Lock-Out ................................................................................ 24 Show Mode........................................................................................... 24 Temperature Sensor .............................................................................. 25 Temperature Adjustment ...................................................................... 25 Temperature Display (?F/?C)................................................................ 25 Cylinder Temperature Display ............................................................. 25
Maintenance ........................................................................................ 27 Daily ..................................................................................................... 27 Monthly................................................................................................. 28 Every Three Months ............................................................................. 29 Every Six Months ................................................................................. 29
Before You Call for Service ............................................................... 31
? Copyright 2001, Alliance Laundry Systems LLC All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
2
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
M414462
Introduction
Model Identification
Information in this manual is applicable to these
models:
25 Pound (220 Liter)
Stacked 30 Pound (300 Liter)
30 Pound (270 Liter)
35 Pound (350 Liter)
Gas
DT0220SFG JT0220SFG ST0220SFG DC0220SFG JC0220SFG SC0220SFG DT0300DFG JT0300DFG ST0300DFG DC0300DFG JC0300DFG SC0300DFG NT0300DRG DT0270SFG JT0270SFG ST0270SFG DC0270SFG JC0270SFG SC0270SFG DT0350SFG JT0350SFG ST0350SFG DC0350SFG JC0350SFG SC0350SFG DT0350SRG
DT0220SRG JT0220SRG ST0220SRG DC0220SRG JC0220SRG SC0220SRG DT0300DRG JT0300DRG ST0300DRG DC0300DRG JC0300DRG SC0300DRG
DT0270SRG JT0270SRG ST0270SRG DC0270SRG JC0270SRG SC0270SRG JT0350SRG ST0350SRG DC0350SRG JC0350SRG SC0350SRG AT0350SRG
Steam
DT0220SSH JT0220SSH ST0220SSH DC0220SSL SC0220SSL
DT0220SSL JT0220SSL ST0220SSL JC0220SSL
DT0300DSH JT0300DSH ST0300DSH DC0300DSL SC0300DSL
DT0300DSL JT0300DSL ST0300DSL JC0300DSL
DT0270SSH JT0270SSH ST0270SSH JC0270SSL JT0270SSL
DT0270SSL ST0270SSL DC0270SSL SC0270SSL
DT0350SSH JT0350SSH ST0350SSH DT0350SSL SC0350SSL
JT0350SSL ST0350SSL DC0350SSL JC0350SSL AT0350SSL
Electric/Other
DT0220SEL JT0220SEL ST0220SEL
DC0220SEL JC0220SEL SC0220SEL
DT0300DEL JT0300DEL ST0300DEL
DC0300DEL JC0300DEL SC0300DEL
DT0270SEL JT0270SEL ST0270SEL
DC0270SEL JC0270SEL SC0270SEL
DT0350SEL JT0350SEL ST0350SEL
DC0350SEL JC0350SEL SC0350SEL
Includes models with MT, EC, OM, CD, RM, EP, CX, CY, EX, EY, NX, NY, ZC, ZR, ZX, ZY, NC and NR control suffixes.
M414462
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
3
Introduction
Information in this manual is applicable to these
models:
50 Pound 75 Pound
ATB50CG STB50CG DTB50CG JTB50CG JT50CG JC50CG JCB50CG SC50CG SCB50CG STB50EG STB75CG DTB75CG JTB75CG ATB75CG JT75CG DTB634 STB75EG
Gas DTB50EG JTB50EG JT50EG JC50EG JCB50EG SC50EG SCB50EG DCB50CG DCB50EG
DTB75EG JTB75EG JT75EG STB634 DCB75CG JCB75CG SCB75CG
120 Pound 170 Pound
ST120FG JT120FG DT120FG SC120FG ST170FG JT170FG JC170FG DC170FG
JC120FG DC120FG AT120FG
SC170FG AT170FG DT170FG
Steam
STB50CSH JTB50CSH DTB50CSH JT50CSH JCB50CSH JC50CSH ATB50CSH
STB50CSL JTB50CSL DTB50CSL JT50CSL SCB50CSH DCB50CSH
STB75CSH JTB75CSH DTB75CSH JT75CSH ATB75CSH STB75CSL SCB75CSL DCB75CSL ST120CSH JT120CSH DT120CSH SC120CSH ST170CSH JT170CSH JC170CSH DC170CSH
JTB75CSL DTB75CSL JT75CSL DCB75CSH JCB75CSH SCB75CSH JCB75CSL
JC120CSH DC120CSH AT120CSH
SC170CSH AT170CSH DT170CSH
Electric/Other
STB50CE JTB50CE DTB50CE JT50CE SC50CE
JCB50CE SCB50CE JC50CE DCB50CE SCB50AT
STB75CE JTB75CE DTB75CE JT75CE DCB75CE
JCB75CE SCB75CE ST75CE JC75CE SC75CE
ST120AT
SC120AT
Not Applicable
Includes models with MT, EC, OM, CD, RM, EP, CX, CY, EX, EY, NX, NY, ZC, ZR, ZX, ZY, NC and NR control suffixes.
Customer Service
If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address of the nearest authorized parts distributor.
For technical assistance, call (920) 748-3121.
Wiring Diagram
The wiring diagram is located in the literature packet supplied with all the non-European models. On European models, it is located in the junction box.
The wiring diagram is inside the electrical junction boxes located on the back of 0300D models, or under the front control panel on 0220S, 0270S, and 0350S models.
4
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
M414462
Nameplate Location
When calling or writing for information about your product, be sure to mention model and serial numbers. Model and serial numbers are located on the nameplate as shown. The model number may also be found inside the door.
MODEL NO:
SERIAL NO:
V-/
HERTZ/ PHASE
AMPS, WIRES + GROUND
TOTAL kW,
MOTOR kW
REQ'D CIRCUIT BREAKER:
AMPS
FAN OUTPUT:
@MAX
"WC STATIC PRESSURE
ANS 72152 CLOTHES DRYER. VOL II
TESTED FOR NATURAL & LIQUID PETROLEUM GASSES
CGA 72
AMPLFIEDRER
EQUIPPED FOR: GAS@ "WC MANIFOLD PRESS.
MIN SUPPLY PRESSURE:
INPUT:
"WC. BTU/hr @
MAX SUPPLY PRESSURE:
BTU/cu.ft.
"WC.
MADE IN U.S.A./FABRIQUE AU ETATS UNIS/FABRICADO EN LOS ESTADOS UNIDOS
70051001
MODEL NO: SERIAL NO:
Introduction
0220S, 0270S, 0350S
T448I
0300D
1
T453I
50 AND 75 POUND TUMBLERS 1
1
120 POUND TUMBLER
170 POUND TUMBLER
1
Nameplate
Figure 1
M414462
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
5
Notes
6
? Copyright, Alliance Laundry Systems LLC ? DO NOT COPY or TRANSMIT
M414462
................
................
In order to avoid copyright disputes, this page is only a partial summary.
To fulfill the demand for quickly locating and searching documents.
It is intelligent file search solution for home and business.
Related download
- tumbler operation maintenance manual
- manual victron energy
- gsa schedule pricelist
- aircraft identification equipment and status
- gov
- code of conduct check the code raytheon
- option 1 raytheon
- 54 veterans resources a community for military veterans
- justification and approval
- reliability of iii v radio frequency rf devices
Related searches
- back operation procedures
- installation and operation qualification
- operation qualification definition
- teavana tumbler parts
- buy starbucks tumbler online
- starbucks tumbler sale
- caterpillar operation and maintenance manual
- hotel operation manual pdf
- state operation manual 2020
- starbucks new tumbler 2020
- cpt manual or cms manual coding instructions
- starbucks coffee tumbler metal